天然产物研究与开发 ›› 2018, Vol. 30 ›› Issue (6): 1037-1045.doi: 10.16333/j.1001-6880.2018.6.020

• 开发研究 • 上一篇    下一篇

龙脑樟去油枝叶中总多酚的酶解-超声辅助提取及抗氧化活性

张峰1，毕良武1,2*，赵振东1,2，王鹏3   

  1. 1中国林业科学研究院林产化学工业研究所 生物质化学利用国家工程实验室 国家林业局林产化学工程重点开放性实验室 江苏省生物质能源与材料重点实验室，南京 210042；2中国林业科学研究院林业新技术研究所，北京 100091；3江西农业大学江西特色林木资源培育与利用2011协同创新中心，南昌 330045
  • 出版日期:2018-07-05 发布日期:2018-07-05
  • 基金资助:

    江西农业大学江西特色林木资源培育与利用2011协同创新中心项目（2013-038）；中国林科院林产化学工业研究所研究团队建设创新工程项目（LHSXKQ2）

Enzymolysis-ultrasonic-assisted Extraction and Antioxidant Activity of Total Polyphenols from Degreasing Cinnamomum caraphora Leaves

ZHANG Feng1,BI Liang-wu1,2*,ZHAO Zhen-dong1,2,WANG Peng3   

  1. 1Institute of Chemical Industry of Forest Products,CAF;National Engineering Lab.for Biomass Chemical Utilization;Key and Open Lab.of Forest Chemical Engineering,SFA;Key Lab.of Biomass Energy and Material,Jiangsu Province,Nanjing 210042,China; 2Institute of New Technology of Forestry,CAF,Beijing 100091,China; 3 2011 Collaborative Innovation Center of Jiangxi Typical Trees Cultivation and Utilization in Jiangxi Agricultural University,Nanchang 330045,China
  • Online:2018-07-05 Published:2018-07-05

PDF (PC)

247

摘要： 为探讨龙脑樟去油枝叶中总多酚的酶解-超声辅助提取工艺，在单因素实验的基础上，通过Box-Behnken设计-响应面法研究纤维素酶用量（X1）、乙醇浓度（X2）、液料比（X3）对龙脑樟去油枝叶中总多酚提取率的影响；同时，以清除DPPH自由基和羟基自由基的能力为评价指标，对总多酚提取物的抗氧化活性进行测定。结果表明，各因素对总多酚提取率的影响顺序为液料比（X3）> 乙醇浓度（X2）>酶用量（X1）；酶解-超声辅助提取龙脑樟去油枝叶中总多酚的最优工艺条件为：酶用量1.9 %，乙醇浓度54%，液料比34 mL/g，酶解温度50 ℃，酶解时间1.5 h，超声时间30 min，超声频率45 kHz，超声功率360 W，超声温度70 ℃；在此条件下，总多酚提取率的平均值为22.08 mg/g，与预测值相近，二次回归模型预测性良好。总多酚提取物对DPPH自由基和羟基自由基的清除作用均呈现量效关系，半数抑制浓度（IC50）值分别为0.36和0.15 mg/mL，表明总多酚提取物具有较强的抗氧化能力。

关键词: 响应面法, 龙脑樟去油枝叶, 酶解-超声辅助提取, 总多酚, 抗氧化活性

Abstract:   In order to investigate enzymolysis-ultrasonic-assisted extraction of total polyphenols from degreasing Cinnamomum caraphora (L.) Presl leaves,Box-Behnken design coupled with response surface analysis based on the single factor experiments was adopted to study the effects of influencing factors including cellulase dosage(X1),ethanol concentration (X2) and liquid-solid ratio (X3) on the extraction rate of total polyphenols.Antioxidant activity of extract of total polyphenols was estimated by testing DPPH radical and hydroxyl radical scavenging ability.The results showed that the effects of above factors on the extraction rate of total polyphenols from degreasing C.caraphora leaves were in the following order:liquid-solid ratio (X3) > ethanol concentration (X2) > cellulase dosage (X1),and the optimal extraction conditions were as follows:1% as cellulase dosage,55% ethanol solution as extraction solution,30 mL/g as ratio of liquid to solid,50 ℃ as enzymolysis temperature,1.5 h as enzymolysis time,30 min as ultrasonic time,45 kHz as ultrasonic frequency,360 W as ultrasonic power,70  ℃ as ultrasonic temperature.Under the optimal conditions,the mean value of extraction rate of total polyphenols reached 22.08 mg/g,which was close to the predicted response value.Therefore,the quadratic regression model can be used to predict the enzymolysis-ultrasonic-assisted extraction conditions of total polyphenols from degreasing C.caraphora leaves.Extract of total polyphenols exhibited a dose-dependent scavenging activity against DPPH radical and hydroxyl radical.Its half maximal inhibitory concentration (IC50) were 0.36 and 0.15 mg/mL,respectively,which suggested extract of total polyphenols had high antioxidant activity.

Key words: Box-Behnken design, degreasing Cinnamomum caraphora , leaves, enzymolysis-ultrasonic-assisted extraction, total polyphenols, antioxidant activity

中图分类号: 

R284.2 Q946

版权所有 © 《天然产物研究与开发》编辑部
地址：四川天府新区群贤南街289号　邮编：610299
电话：028-85210304　QQ群：342035423　Email：trcw@clas.ac.cn; re_trcw@clas.ac.cn　
本系统由北京玛格泰克科技发展有限公司设计开发
总访问量：　今日访问：　在线人数：